8970952627

Strojmśki vestnik - Journal ofMechanical Engmeenng 56(2010)9. 544-550

metal sheets to the monocock s tnie turę which provides the latter with reinforcement and at the same time solves the issues of noise and temperaturę isolatiou, vibrations, uneven surfaces etc.

2 A MONOCOCK, THE SELF-BEARING BUS CONSTRUCTION

Monocock is the self-bearing construction for fitting of the propulsion system of the vehicle: the engine, the clutch, the transmission gears, the suspension, the axles and individual sets of the braking, steering and other systems.

Due to this function, the monocock is an essential part of the bus as it has to be desigued in a way which enables an unintemipted and simple fitting of all the systems and aggregates to their pre-detennined installation positions. The self-bearing monocock constniction is a step forward and represents a pre-defmed fonu, design and function. In addition, all analyses of the crash impact tests are taken into account.

3 THE APPLICATION OF THE FEA METHOD

A lineai' modular analysis FEA is used to determine the basis for the analysis and testing of the strength with an experimental method. Tlie objective is detennination or a rough estimation of the load and defonnations ofthe monocock.

Fig. 1. FEA with a local concentration oftension

Morę specific data are only obtained experimentally using the strain gauge, i.e. by applying the method of measuring the strength with electrical resistance. Tlie FEA model only served to determine the locations where the measuring tapes will be applied (Fig. 1).

On the most loaded locations 32 points were determined at which measuring tapes were adliered to the fiamework at an eai ly stage of the monocock constniction. In this phase the staiting values of defonnations and strength were determined which had a »zero value« in the fmished bus - tlie system was re-set and the bus's own defonnations were neutralised after the installation of the bus eąuipment; so in measurements only absolute values were taken into account.

Combinations of measuring tapes (Fig. 2) which registered defonnations in all directions, i.e. in x, y, z orientations, were used. Tliese were lineai' measuring tapes and rosettes which are nonnally used in measuring composed loads and defonnations.

Fig. 2. Adherence ofthe measuring tapes

4 PREPARATION OF THE CONSTRUCTION FOR MEASUREMENT

Tlie self-bearing bus constniction was tested using the measuring tapes on 32 locations (Fig. 3) which were determined after a preliminary analysis and a FEA calculation. Tlie most critical points were the comers of the six bus doors which was also indicated by the tension measurement [2],

Tlie bus in the monocock fonii was tested statically and dynamically. Tlie testing was canied out for different cases of the fiamework

The Strength of the Bus Structwe with the Determnation of Cntical Points

Wyszukiwarka

Podobne podstrony:
Paper received 19 03 2010 Paper accepted: 15 07 2010 Strojmśki vestmk - Journal of Mechamcal Engmeer
56 Table 2.1 Sample sizes presented relative to the number of capture per bird. 1 Number of
56 Table 2.1 Sample sizes presented relative to the number of capture per bird. 1 Number of
Prejeto 22 09 2009 Sprejeto 24 05 2010 Strojmśki yestmk - Journal of Mechanical Engineenng 56(2010)9
diagnostyka laboratoryjna Journal of Laboratory Dlagnostlc 2010 • Volume 46 • Number 4 • 421-427 Pra
diagnostyka laboratoryjna Journal of Laboratory Diagnostics 2010 • Volume 46 • Number2 •
BioLetyn 1/IV/2010 idziatem...Back to the lab again — impreza biotechnologów Już po raz drugi w tym
56 to draw attention to the fact that not everything the Vedic Aryans introduced into Indian civiliz
k1? PWSZ Leszno - Instytut Ekonomii i Zarządzania rok akademicki 2010/2011 Makroekonomia - ćwiczenia
ksiadz marek
5 30 (sc. V. w. 5—6). Jak z tego wynika, przyszła Polska to dziecię rodź? ce się w męcz
Dilip Sarkar Hearts of Oak, The Human Tragedy of HMS Royal Oak (2010) DILIP SARKAR HEARTS OF OAK T
56 (196) -2- FO 3434RE-30 A Sea Org member may also be sent straight to the RPF s RPF for exceedingl
56 (229) (T) Pokoloruj autobus tak, aby to co czerwone było żółte, a to co żółte - czerwone.
56 (315) 3.5.5C. Non-specific technique for the deep ventral muscles to increase dorsal flexion

więcej podobnych podstron